Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part - Vauxhall Insignia all Electrical Components

The BBC has Replsce its cookie policy. We use cookies to ensure that we give you the best experience on our website. This includes cookies from third party social media websites if you visit a page which contains embedded content from social media. Such third party cookies may track your use of the BBC website. We and our partners also use cookies to ensure we show you advertising that is relevant to you.

If you continue without changing your settings, we'll assume that you are happy to receive all cookies Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part the BBC website. However, you can change your cookie settings at Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part time.

One of Vauxhall's Electrjcal cars, The Insignia, was Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part in and crowned European Car of the Year just one year later. However, if you're unlucky, the car could lose power while you are steering, flammable fluid could leak into your engine and, according to some experts, Electricwl car could even burst into flames.

Martin Webb bought his new Vauxhall Insignia in April He was only notified when a car pulled alongside him Vaudhall told him that there were flames coming out the back of the car. Martin and his wife got out of the car just as the fire had taken hold. If the fire brigade had been two more minutes, there would have been nothing left. Although Martin and his wife were badly shaken, neither were hurt. The car, on the Mini One R50 R53 R52 2001-2007 Banner Power Bull 62Ah Battery Replacement hand, was a write-off.

So what was it that caused Martin's Insignia to burst into flames so dramatically? He says the reason given by Vauxhall over the phone was that the pipe on the power steering had come off and the fluid had dropped onto the diesel particulate filter and ignited, as the diesel particulate filter gets very hot. Vauxhall later commissioned a forensic report. It didn't find the exact cause of the fire, but said that it was fluid based. It ruled out fuel or Lancia Delta Mk2 1993-1999 Bosch S4 Battery 42Ah Electrical System Replace Part, and it also appeared to support the theory that power assisted steering fluid had escaped, causing the blaze.

The report identified staining on the heat shield of the diesel particulate filter - the device that removes soot from the exhaust. Car expert, John Dabek explains that power steering fluid is an hydraulic oil, and like any oil it is combustible: If this was to fail, fluid could find its way into the exhaust. Depending on how hot that part of the exhaust system gets, you Battegy Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part risk of this vehicle catching fire.

As Martin's 2009-206 was a diesel, it means that if there was any leakage of hydraulic oil, pressurised from this pipe then it could find its way on to the exhaust system which contains the diesel particulate filter - Pqrt according to John Dabek is arguably the hottest part of the exhaust system, which means the effects of that could be quite serious.

Vauxhall now say their own investigations have ruled out this possibility, and that no Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part was found with the high pressure hose or fittings, but they also say the cause of the fire remains unknown. Vauxhall have also identified a fault in some other Insignia models, which according to some experts, could result in fire. And how do we know that? We got our hands on what Vauxhall refers Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part as a 'Technical Service Bulletin'.

It's a document that Vauxhall distributes internally to mechanics when something has gone wrong with one of their vehicles and a part needs replacing. The report that we have, which is dated Octoberrefers to the pipe that carries the power steering fluid and it's pretty clear: So what could be the consequences 20092-016 failing to remedy this 'insufficient design'?

According to John Dabek, there's a potential situation where Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part can have a failure of a power steering Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part under pressure, meaning that drivers could lose power assistance to their steering, which is could be quite. There is also the potential for power assisted steering fluid to spray onto Bsttery hot part of the exhaust, the diesel particulate filter, that can cause smoke - and in the worst case, could cause a fire.

However, Vauxhall say that if power steering fluid does escape from a pipe, it will leak out slowly, rather than be sprayed across the engine. But how reassuring is that?

Automotive engineer, Mark Brown, explains: A leak once started can, and usually does, worsen of its own volition owing to the nature of the reason the leak starts in the first place - so even a slow leak presents a serious fire hazard.

Vauxhall says the fault affects 6, vehicles, all manufactured in Germany between andand they told us it cannot state categorically that no fluid would, under any circumstances, come into contact with a part of the engine where a fire could potentially result. Instead, the fault is being fixed only when owners put them in for service. Mark Brown highlights that there are two potential hazards here caused by one fault; the first is the leakage of power steering fluid that could lead to a loss of power steering assistance which may or may not be rapid or sudden depending on the level of leakage.

The second is the fact that because there is a significant risk of fire from the leakage of any power steering fluid which is flammable, this makes it a safety issue which needs to be sorted immediately. John Dabek also flags up that Vauxhall have known about this for some time: In fact, Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part been putting it right on the quiet when the vehicles have been in for servicing.

Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part

That's not good. They should find the vehicles affected, bring them in by issuing a recall and then getting them properly sorted. Martin Webb's vehicle is not in the range of vehicles is impacted by the service action. There is no evidence of a connection between the fire and the power steering system service action. Vauxhall has no record of the content of the alleged telephone call to Mr Webb.

Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part initial response to Mr Webb following an inspection of his complete vehicle was that there could have Electrlcal a potential low pressure fluid leak but this was not necessarily directed at the steering. Subsequent expert 072 / 096R Titanium Car Van Battery 70Ah - E12, S4009, S 4009 of individual components, including the high pressure hose, concluded that there was no fault with the high pressure hose or fittings.

The cause of this fire remains unknown. Vauxhall takes every incident of a vehicle fire very Vauxhakl Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part case is thoroughly investigated together with specialists and insurance companies to determine the root cause and consequently, ensure the continuing safety of its vehicles.

This is a complicated task, many individual root causes are possible - customer misuse, incorrect vehicle repair, electrical systems, fuel systems, mechanical friction or other external influences.

The 2009--2016 action was to deal with a slow leak from the power steering pipe joint and is not safety related either in terms of rapid loss of steering assistance or fire. There are no instances where the slow leak has resulted in a vehicle fire. The decision to handle this Eelctrical a service update minimises the inconvenience to customers. The service action refers only to diesel-engined vehicles, petrol-engined vehicles are not affected.

None of the vehicles within the Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part action range that has been inspected has either exhibited a leak or shown other than a slow leak of fluid even though the system is pressurised. There Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part also no evidence that movement of or within the engine has caused the leak to worsen or spread.

Vauxhall cannot state categorically that no fluid would, under any circumstances, come into contact with a part of the engine where a fire could potentially result. Should fluid leak from the joint specified in the service action, it would do so slowly. The reservoir containing the fluid Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part atmospheric pressure is relatively large and any persistent leak from this reservoir Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part become Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part - either on the ground or at the point of the vehicle being serviced.

Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part

Vauxhall Insignia issues???

Power assistance would only be lost when the reservoir is. Even at this point the driver would only lose assistance and not steering control. Evidence Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part loss of assistance would be most noticeable at parking speeds and up to mph.

Above this speed the steering would be 'heavier', akin to a manually Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part car without power assisted steering.

If customers have any concerns about their vehicle, Vauxhall is always happy to arrange for an inspection at a local Vauxhall retailer. Customers who may Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part to ascertain whether their Insignia is the subject of the service action should contact their local retailer who can advise if their vehicle is within the range Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part if so, whether or not it has already been reworked.

Vauxhall retailer locations can be found at: Discover ways to avoid being scammed and find useful consumer tips and hints. Continue Change settings Find out. Company Peugeot 406 8B 8C 8E/F 1995-2004 Banner Power Bull 62Ah Battery Replacement Martin Webb's vehicle is not in the range of vehicles is impacted by the service action.

Consumer advice Discover ways Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part avoid being scammed and find useful consumer tips and hints.

Vauxhall Insignia 2009-2016 Vetech Battery 55Ah Electrical System Replace Part

You may also like. Similar programmes By genre: Home Schedule TV Guide require ["jquery

Leave a comment